Item Affected: POWER TRAIN:AUTOMATIC TRANSMISSION
Date Announced: 04/26/1999
Description of Recall: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 4T65E AUTOMATIC TRANSMISSIONS. THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE." A RETAINING CLIP, WHICH SECURES THE MANUAL VALVE TO THE LINKAGE OF THE TRANSMISSION DETENT LEVER, CAN BECOME LOOSE UNDER A COMBINATION OF POSSIBLE DRIVER SHIFTING MANEUVERS AND ALLOW THE LINK TO BECOME DISCONNECTED FROM THE MANUAL VALVE.
Conequence: IF THE LINK DISCONNECTS, THE DRIVER'S INDICATED PRNDL STATE MAY DIFFER FROM THE HYDRAULIC STATE OF THE TRANSMISSION. IF THE DRIVER SELECTS 'DRIVE' AND THE TRANSMISSION IS ACTUALLY IN 'REVERSE', A VEHICLE CRASH COULD OCCUR.
Action Need To Fix It: DEALERS WILL REPLACE THE MANUAL VALVE/LINK ASSEMBLY WITH A REPLACEMENT MANUAL VALVE/LINK KIT, FEATURING A SPRING-TYPE FASTENER.
Notes: OWNER NOTIFICATION BEGAN MAY 25, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Item Affected: FUEL SYSTEM, GASOLINE:DELIVERY
Date Announced: 02/24/2004
Description of Recall: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Conequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Action Need To Fix It: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
Notes: GM RECALL NO. 03054B. SEE CAMPAIGN 03V-473 FOR ADDITIONAL UNITS. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Item Affected: FUEL SYSTEM, GASOLINE:DELIVERY
Date Announced: 02/24/2004
Description of Recall: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Conequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Action Need To Fix It: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
Notes: GM RECALL NO. 03054B. SEE CAMPAIGN 03V-473 FOR ADDITIONAL UNITS. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Item Affected: ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE
Date Announced: 10/23/1995
Description of Recall: THESE VEHICLES WERE ASSEMBLED WITH A MALFUNCTION ALARM, LIGHTING AND LOCKING (MALL) MODULE THAT CAN CONTAIN A DAMAGED CAPACITOR. IF THE CAPACITOR IS DAMAGED, THE "KEY IN THE IGNITION" WARNING CHIME AND THE DRIVER SEAT BELT UNBUCKLED WARNING CHIME AND INDICATOR LAMP MAY NOT WORK. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION" AND FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." IN ADDITION, OTHER CHIME REMINDER FUNCTIONS, INTERIOR LIGHTING CONTROLS, AND POWER DOOR LOCKING FEATURES ARE ALSO AFFECTED.
Conequence: CONSEQUENCE OF NON-COMPLIANCE; THE DRIVER MAY NOT BE AWARE THAT THE KEY WAS LEFT IN THE IGNITION OR THAT THE SAFETY BELT WAS NOT BUCKLED.
Action Need To Fix It: DEALERS WILL INSPECT AND, IF REQUIRED, REPLACE THE MALL MODULE.
Notes: SYSTEM: ELECTRICAL; IGNITION; ANTI-THEFT; FMVSS NO. 114 AND NO. 208. VEHICLE DESCRIPTION: PASSENGER VEHICLES. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300; OLDSMOBILE AT 1-800-442-6537; OR PONTIAC AT 1-800-762-2737. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Item Affected: FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
Date Announced: 07/01/1996
Description of Recall: A BACKFIRE DURING ENGINE STARTING CAN CAUSE BREAKAGE OF THE UPPER INTAKE MANIFOLD.
Conequence: THIS CONDITION CAN CAUSE A NO-START CONDITION AND POSSIBLY AN ENGINE COMPARTMENT FIRE.
Action Need To Fix It: DEALERS WILL UPDATE THE POWERTRAIN CONTROL MODULE PROGRAMMING. UNTIL THE CAMPAIGN REPAIR IS MADE, THE VEHICLE HOOD SHOULD BE SHUT WHENEVER STARTING THE VEHICLE TO REDUCE THE CHANCE OF PERSONAL INJURY.
Notes: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 3.8L V6 ENGINE. OWNER NOTIFICATION: OWNER NOTIFICATIONS BEGAN DURING JULY 1996. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300; PONTIAC AT 1-800-762-2737; OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Item Affected: ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT CONTROLLER
Date Announced: 10/23/1995
Description of Recall: THESE VEHICLES WERE ASSEMBLED WITH A MALFUNCTION ALARM, LIGHTING AND LOCKING (MALL) MODULE THAT CAN CONTAIN A DAMAGED CAPACITOR. IF THE CAPACITOR IS DAMAGED, THE "KEY IN THE IGNITION" WARNING CHIME AND THE DRIVER SEAT BELT UNBUCKLED WARNING CHIME AND INDICATOR LAMP MAY NOT WORK. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION" AND FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." IN ADDITION, OTHER CHIME REMINDER FUNCTIONS, INTERIOR LIGHTING CONTROLS, AND POWER DOOR LOCKING FEATURES ARE ALSO AFFECTED.
Conequence: CONSEQUENCE OF NON-COMPLIANCE; THE DRIVER MAY NOT BE AWARE THAT THE KEY WAS LEFT IN THE IGNITION OR THAT THE SAFETY BELT WAS NOT BUCKLED.
Action Need To Fix It: DEALERS WILL INSPECT AND, IF REQUIRED, REPLACE THE MALL MODULE.
Notes: SYSTEM: ELECTRICAL; IGNITION; ANTI-THEFT; FMVSS NO. 114 AND NO. 208. VEHICLE DESCRIPTION: PASSENGER VEHICLES. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300; OLDSMOBILE AT 1-800-442-6537; OR PONTIAC AT 1-800-762-2737. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Item Affected: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
Date Announced: 08/02/1994
Description of Recall: A SPRING IN THE HEAD LAMP PORTION OF THE HEAD PARK LAMP SWITCH CAN FAIL PREVENTING LATCHING OF THE HEAD LAMP PORTION OF THE SWITCH IN THE "ON" POSITION.
Conequence: THE HEAD LAMPS WOULD NOT STAY ILLUMINATED RESULTING IN REDUCED DRIVER VISIBILITY.
Action Need To Fix It: DEALERS WILL INSPECT HEAD/PARK LAMP SWITCH BUILD DATE CODES AND REPLACE SWITCHES WITH SUSPECT DATE CODES.
Notes: SYSTEM: LIGHTING, SWITCH, BUTTON; RING; HEADLIGHTS. VEHICLE DESCRIPTION: PASSENGER CARS. NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT OLDSMOBILE SERVICE CENTER AT 1-800-442-6537. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Item Affected: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
Date Announced: 08/02/1994
Description of Recall: A SPRING IN THE HEAD LAMP PORTION OF THE HEAD PARK LAMP SWITCH CAN FAIL PREVENTING LATCHING OF THE HEAD LAMP PORTION OF THE SWITCH IN THE "ON" POSITION.
Conequence: THE HEAD LAMPS WOULD NOT STAY ILLUMINATED RESULTING IN REDUCED DRIVER VISIBILITY.
Action Need To Fix It: DEALERS WILL INSPECT HEAD/PARK LAMP SWITCH BUILD DATE CODES AND REPLACE SWITCHES WITH SUSPECT DATE CODES.
Notes: SYSTEM: LIGHTING, SWITCH, BUTTON; RING; HEADLIGHTS. VEHICLE DESCRIPTION: PASSENGER CARS. NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT OLDSMOBILE SERVICE CENTER AT 1-800-442-6537. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Item Affected: POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
Date Announced: 01/23/1996
Description of Recall: VEHICLE DESCRIPTION: PASSENGER VEHICLES MANUFACTURED FROM AUGUST 1991 THROUGH JULY 1995. THE TRANSMISSION OIL COOLER LINE CAN SEPARATE WHEN THE VEHICLE IS OPERATED IN LOW TEMPERATURES IN COMBINATION WITH HIGH TRANSMISSION LOADS.
Conequence: VEHICLE FIRES CAN OCCUR DUE TO THE SPILLAGE OF TRANSMISSION FLUID.
Action Need To Fix It: DEALERS WILL REPLACE THE TRANSMISSION OIL COOLER LINES.
Notes: SYSTEM: POWER TRAIN; TRANSMISSION; AUTOMATIC; COOLING UNIT AND LINES. VEHICLE DESCRIPTION: PASSENGER MINI-VANS WITH 3.8L ENGINE AND 4-SPEED AUTOMATIC TRANSMISSIONS AND PASSENGER VEHICLES WITH L27 OR L67 ENGINE AND 4T60E AUTOMATIC TRANSMISSIONS AND SOLD OR REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, VERMONT, WEST VIRGINIA, WISCONSIN AND WYOMING. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020; OLDSMOBILE AT 1-800-442-6537; PONTIAC AT 1-800-762-2737; OR BUICK AT 1-800-521-7300. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Item Affected: POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
Date Announced: 01/23/1996
Description of Recall: VEHICLE DESCRIPTION: PASSENGER VEHICLES MANUFACTURED FROM AUGUST 1991 THROUGH JULY 1995. THE TRANSMISSION OIL COOLER LINE CAN SEPARATE WHEN THE VEHICLE IS OPERATED IN LOW TEMPERATURES IN COMBINATION WITH HIGH TRANSMISSION LOADS.
Conequence: VEHICLE FIRES CAN OCCUR DUE TO THE SPILLAGE OF TRANSMISSION FLUID.
Action Need To Fix It: DEALERS WILL REPLACE THE TRANSMISSION OIL COOLER LINES.
Notes: SYSTEM: POWER TRAIN; TRANSMISSION; AUTOMATIC; COOLING UNIT AND LINES. VEHICLE DESCRIPTION: PASSENGER MINI-VANS WITH 3.8L ENGINE AND 4-SPEED AUTOMATIC TRANSMISSIONS AND PASSENGER VEHICLES WITH L27 OR L67 ENGINE AND 4T60E AUTOMATIC TRANSMISSIONS AND SOLD OR REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, VERMONT, WEST VIRGINIA, WISCONSIN AND WYOMING. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020; OLDSMOBILE AT 1-800-442-6537; PONTIAC AT 1-800-762-2737; OR BUICK AT 1-800-521-7300. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.